Problem s IDE diskom

[Staniclav Sitar]

Vazeni pani.

Nainstaloval som v jednej malej firme velmi jednoduchy fileserver.

Po skusenostiach s raidom v RedHat Linuxe som tentokrat siahol
po FreeBSD 5.2.1 a vinum. To je krasa!

Nainstaloval som "vanilla" FreeBSD 5.2.1 plus samba, mc a Vim.

Vytvoril som dva zrkadlene Vinum oddiely (volumes).
Dal som ich zdielat cez Sambu.  Jeden s RW pristupom pre kazdeho a druhy
ReadOnly. Urobil som maly skript, ktory jeden (maly) adresar na RW oddieli
kazdu noc o 2:00 zbali to tgz archivu a ulozi na RO oddiel.

System bezal krasne niekolko dni a potom sa zacali diat veci.
.........
ad2: WARNING - READ_DMA UDMA ICRC error (retrying request) LBA=16643886
.........
ad2: FAILURE - READ_DMA status=51<READY,DSC,ERROR> 
error=84<ICRC,ABORTED> LBA=16720430
vinum: zrkadlo1.p1.s0 is crashed by force
vinum: zrkadlo1.p1 is faulty
fatal:zrkadlo1.p1.s0 read error, block 12527465 for 65536 bytes
zrkadlo1.p1.s0: user buffer block 12527200 for 65536 bytes
vinum: zrkadlo1.p1.s0 is stale by force

Disk ad2 je pripojeny na ako master a CDROM je ako slave
Disk ad2 je presne totozny s ad1 (ad1 je na IDE kabli samostatne)

Poradte mi prosim.
Mam reklamovat disk? - ostatne particie zatial zda sa bezia a predpokladam
ze mi reklamaciu len tak neuznaju.
Vcera som skopiroval cca 5GB dat z jednej Vinum particie na inu, na 
ktorej su obidva
plexy up a jeden ten plex je na tom "podozrivom" disku a ziadna chyba sa
neprejavila.


Prikladam kusok zo suboru /var/log/mesages

......... System bezi, nic sa nedeje ......
May 15 22:10:47 server kernel: ep0: Ethernet address 00:50:04:f9:b0:9a
May 15 22:10:47 server kernel: unknown: <PNP0303> can't assign resources 
(port)
May 15 22:10:47 server kernel: unknown: <PNP0a03> can't assign resources 
(port)
May 15 22:10:47 server kernel: unknown: <PNP0501> can't assign resources 
(port)
May 15 22:10:47 server kernel: unknown: <PNP0700> can't assign resources 
(port)
May 15 22:10:47 server kernel: unknown: <PNP0400> can't assign resources 
(port)
May 15 22:10:47 server kernel: unknown: <PNP0501> can't assign resources 
(port)
May 15 22:10:47 server kernel: Timecounter "TSC" frequency 549064407 Hz 
quality 800
May 15 22:10:47 server kernel: Timecounters tick every 10.000 msec
May 15 22:10:47 server kernel: GEOM: create disk ad0 dp=0xc20a4c60
May 15 22:10:47 server kernel: ad0: 38166MB <ST340014A> [77545/16/63] at 
ata0-master UDMA33
May 15 22:10:47 server kernel: acd0: CDROM <ATAPI 44X CDROM> at 
ata0-slave PIO4
May 15 22:10:47 server kernel: GEOM: create disk ad2 dp=0xc20a4360
May 15 22:10:47 server kernel: ad2: 38166MB <ST340014A> [77545/16/63] at 
ata1-master UDMA33
May 15 22:10:47 server kernel: Waiting 15 seconds for SCSI devices to settle
May 15 22:10:47 server kernel: Mounting root from ufs:/dev/ad0s1a
May 20 02:00:04 server kernel: ad2: WARNING - READ_DMA UDMA ICRC error 
(retrying request) LBA=16643886
May 22 02:00:17 server kernel: ad2: WARNING - READ_DMA UDMA ICRC error 
(retrying request) LBA=16720046
May 22 02:00:17 server kernel: ad2: WARNING - READ_DMA UDMA ICRC error 
(retrying request) LBA=16720046
May 23 02:00:17 server kernel: ad2: WARNING - READ_DMA UDMA ICRC error 
(retrying request) LBA=16721518
May 23 12:31:30 server kernel: ad2: WARNING - READ_DMA UDMA ICRC error 
(retrying request) LBA=16716070
May 25 02:00:18 server kernel: ad2: WARNING - READ_DMA UDMA ICRC error 
(retrying request) LBA=16721134
May 26 02:00:18 server kernel: ad2: WARNING - READ_DMA UDMA ICRC error 
(retrying request) LBA=16720430
May 26 02:00:19 server kernel: ad2: WARNING - READ_DMA UDMA ICRC error 
(retrying request) LBA=16720430
May 26 02:00:19 server kernel: ad2: FAILURE - READ_DMA 
status=51<READY,DSC,ERROR> error=84<ICRC,ABORTED> LBA=16720430
May 26 02:00:19 server kernel: vinum: zrkadlo1.p1.s0 is crashed by force
May 26 02:00:19 server kernel: vinum: zrkadlo1.p1 is faulty
May 26 02:00:19 server kernel: fatal:zrkadlo1.p1.s0 read error, block 
12527465 for 65536 bytes
May 26 02:00:19 server kernel: zrkadlo1.p1.s0: user buffer block 
12527200 for 65536 bytes
May 26 02:00:29 server kernel: vinum: zrkadlo1.p1.s0 is stale by force
May 29 16:36:55 server login: ROOT LOGIN (root) ON ttyv1
May 29 16:39:25 server shutdown: reboot by root:
May 29 16:39:27 server syslogd: exiting on signal 15
May 29 16:41:25 server syslogd: kernel boot file is /boot/kernel/kernel
May 29 16:41:25 server kernel: Copyright (c) 1992-2004 The FreeBSD Project.
May 29 16:41:25 server kernel: Copyright (c) 1979, 1980, 1983, 1986, 
1988, 1989, 1991, 1992, 1993, 1994
May 29 16:41:25 server kernel: The Regents of the University of 
California. All rights reserved.
May 29 16:41:25 server kernel: FreeBSD 5.2.1-RELEASE #0: Mon Feb 23 
20:45:55 GMT 2004
May 29 16:41:25 server kernel: 
root at wv1u.btc.adaptec.com:/usr/obj/usr/src/sys/GENERIC
May 29 16:41:25 server kernel: Preloaded elf kernel 
"/boot/kernel/kernel" at 0xc09e3000.
May 29 16:41:25 server kernel: Timecounter "i8254" frequency 1193182 Hz 
quality 0
May 29 16:41:25 server kernel: CPU: Intel Pentium III (549.06-MHz 
686-class CPU)
May 29 16:41:25 server kernel: Origin = "GenuineIntel"  Id = 0x681  
Stepping = 1
May 29 16:41:25 server kernel: 
Features=0x383f9ff<FPU,VME,DE,PSE,TSC,MSR,PAE,MCE,CX8,SEP,MTRR,PGE,MCA,CMOV,PAT,PSE36,MMX,FXSR,SSE>
May 29 16:41:25 server kernel: real memory  = 134152192 (127 MB)
May 29 16:41:25 server kernel: avail memory = 120692736 (115 MB)
May 29 16:41:25 server kernel: Pentium Pro MTRR support enabled
May 29 16:41:25 server kernel: npx0: [FAST]
May 29 16:41:25 server kernel: npx0: <math processor> on motherboard
May 29 16:41:25 server kernel: npx0: INT 16 interface
May 29 16:41:25 server kernel: pcibios: BIOS version 2.10
May 29 16:41:25 server kernel: Using $PIR table, 7 entries at 0xc00fda30
May 29 16:41:25 server kernel: pcib0: <Intel 82443BX (440 BX) host to 
PCI bridge> at pcibus 0 on motherboard
May 29 16:41:25 server kernel: pci0: <PCI bus> on pcib0
May 29 16:41:25 server kernel: pci_cfgintr: 0:7 INTD BIOS irq 11
May 29 16:41:25 server kernel: pci_cfgintr: 0:12 INTA BIOS irq 10
May 29 16:41:25 server kernel: agp0: <Intel 82443BX (440 BX) host to PCI 
bridge> mem 0xe8000000-0xebffffff at device 0.0 on pci0
May 29 16:41:25 server kernel: pcib1: <PCI-PCI bridge> at device 1.0 on pci0
May 29 16:41:25 server kernel: pci1: <PCI bus> on pcib1
May 29 16:41:25 server kernel: pci1: <display, VGA> at device 0.0 (no 
driver attached)
May 29 16:41:25 server kernel: isab0: <PCI-ISA bridge> at device 7.0 on pci0
May 29 16:41:25 server kernel: isa0: <ISA bus> on isab0
May 29 16:41:25 server kernel: atapci0: <Intel PIIX4 UDMA33 controller> 
port 0xf000-0xf00f at device 7.1 on pci0
May 29 16:41:25 server kernel: ata0: at 0x1f0 irq 14 on atapci0
May 29 16:41:25 server kernel: ata0: [MPSAFE]
May 29 16:41:25 server kernel: ata1: at 0x170 irq 15 on atapci0
May 29 16:41:25 server kernel: ata1: [MPSAFE]
May 29 16:41:25 server kernel: uhci0: <Intel 82371AB/EB (PIIX4) USB 
controller> port 0xe000-0xe01f irq 11 at device 7.2 on pci0
May 29 16:41:25 server kernel: usb0: <Intel 82371AB/EB (PIIX4) USB 
controller> on uhci0
May 29 16:41:25 server kernel: usb0: USB revision 1.0
May 29 16:41:25 server kernel: uhub0: Intel UHCI root hub, class 9/0, 
rev 1.00/1.00, addr 1
May 29 16:41:25 server kernel: uhub0: 2 ports with 2 removable, self powered
May 29 16:41:25 server kernel: piix0: <PIIX Timecounter> port 
0x5000-0x500f at device 7.3 on pci0
May 29 16:41:25 server kernel: Timecounter "PIIX" frequency 3579545 Hz 
quality 0
May 29 16:41:25 server kernel: ahc0: <Adaptec aic7880 Ultra SCSI 
adapter> port 0xe400-0xe4ff mem 0xed000000-0xed000fff irq 10 at device 
12.0 on pci0
May 29 16:41:25 server kernel: aic7880: Ultra Wide Channel A, SCSI Id=7, 
16/253 SCBs
May 29 16:41:25 server kernel: orm0: <Option ROM> at iomem 
0xc0000-0xc7fff on isa0
May 29 16:41:25 server kernel: pmtimer0 on isa0
May 29 16:41:25 server kernel: atkbdc0: <Keyboard controller (i8042)> at 
port 0x64,0x60 on isa0
May 29 16:41:25 server kernel: atkbd0: <AT Keyboard> flags 0x1 irq 1 on 
atkbdc0
May 29 16:41:25 server kernel: kbd0 at atkbd0
May 29 16:41:25 server kernel: fdc0: <Enhanced floppy controller 
(i82077, NE72065 or clone)> at port 0x3f7,0x3f0-0x3f5 irq 6 drq 2 on isa0
May 29 16:41:25 server kernel: fdc0: FIFO enabled, 8 bytes threshold
May 29 16:41:25 server kernel: fd0: <1440-KB 3.5" drive> on fdc0 drive 0
May 29 16:41:25 server kernel: ppc0: <Parallel port> at port 0x378-0x37f 
irq 7 on isa0
May 29 16:41:25 server kernel: ppc0: Generic chipset (NIBBLE-only) in 
COMPATIBLE mode
May 29 16:41:25 server kernel: ppbus0: <Parallel port bus> on ppc0
May 29 16:41:25 server kernel: plip0: <PLIP network interface> on ppbus0
May 29 16:41:25 server kernel: lpt0: <Printer> on ppbus0
May 29 16:41:25 server kernel: lpt0: Interrupt-driven port
May 29 16:41:25 server kernel: ppi0: <Parallel I/O> on ppbus0
May 29 16:41:25 server kernel: sc0: <System console> at flags 0x100 on isa0
May 29 16:41:25 server kernel: sc0: VGA <16 virtual consoles, flags=0x300>
May 29 16:41:25 server kernel: sio0 at port 0x3f8-0x3ff irq 4 flags 0x10 
on isa0
May 29 16:41:25 server kernel: sio0: type 16550A
May 29 16:41:25 server kernel: sio1 at port 0x2f8-0x2ff irq 3 on isa0
May 29 16:41:25 server kernel: sio1: type 16550A
May 29 16:41:25 server kernel: vga0: <Generic ISA VGA> at port 
0x3c0-0x3df iomem 0xa0000-0xbffff on isa0
May 29 16:41:25 server kernel: ep0: <3Com 3C509-TPC EtherLink III> at 
port 0x220-0x22f irq 5 on isa0
May 29 16:41:25 server kernel: ep0: Ethernet address 00:50:04:f9:b0:9a
May 29 16:41:25 server kernel: unknown: <PNP0303> can't assign resources 
(port)
May 29 16:41:25 server kernel: unknown: <PNP0a03> can't assign resources 
(port)
May 29 16:41:25 server kernel: unknown: <PNP0501> can't assign resources 
(port)
May 29 16:41:25 server kernel: unknown: <PNP0700> can't assign resources 
(port)
May 29 16:41:25 server kernel: unknown: <PNP0400> can't assign resources 
(port)
May 29 16:41:25 server kernel: unknown: <PNP0501> can't assign resources 
(port)
May 29 16:41:25 server kernel: Timecounter "TSC" frequency 549064661 Hz 
quality 800
May 29 16:41:25 server kernel: Timecounters tick every 10.000 msec
May 29 16:41:25 server kernel: GEOM: create disk ad0 dp=0xc20a4c60
May 29 16:41:25 server kernel: ad0: 38166MB <ST340014A> [77545/16/63] at 
ata0-master UDMA33
May 29 16:41:25 server kernel: acd0: CDROM <ATAPI 44X CDROM> at 
ata0-slave PIO4
May 29 16:41:25 server kernel: GEOM: create disk ad2 dp=0xc20a4360
May 29 16:41:25 server kernel: ad2: 38166MB <ST340014A> [77545/16/63] at 
ata1-master UDMA33
May 29 16:41:25 server kernel: Waiting 15 seconds for SCSI devices to settle
May 29 16:41:25 server kernel: Mounting root from ufs:/dev/ad0s1a
May 29 16:41:43 server login: ROOT LOGIN (root) ON ttyv1


Dakujem
Stano